Audenreid

Damage from 2006 Flood

2006-08-22T10:22:00.000-04:00

Flow rates were estimated at nearly 300,000 gpm. The previous high flow was recorded at 30,000 gpm

Black discharge during 2006 Flood

2006-08-22T10:20:00.000-04:00

Audenreid Dedication

2006-08-22T10:15:00.000-04:00

Audenreid Dedication

2006-08-22T10:14:00.000-04:00

2006-05-25T09:04:00.000-04:00

DIRECTIONS TO BRANDONVILLE FIRE COMPANY
& AUDENREID TREATMENT SYSTEM

FROM BLOOMSBURG:

Rte. 487 South to Mainville Road. Take Mainville Road towards MAINVILLE. Mainville Road Turns into PA-339. Continue on PA-339 to PA- 924 (approx. 15 miles). Turn Right onto PA-924.

BRANDONVILLE FIRE CO. (for the bus): Located at the intersection of PA-924 and PA-339, approximately ½ mile after your right turn onto PA-924. (Map A)

FROM HAZELTON:

BRANDONVILLE FIRE CO. (for the bus): Take PA-924 South (approx. 13 miles). Go straight through 924/ 339 intersection. Follow above directions. (Map A)

FROM FRACKVILLE:

BRANDONVILLE FIRE CO. (for the bus): Take 924 North to Brandonville (approx. 8 miles). Look for Fire Company on your right. Or, East Brandon Street will be on your left past the Fire Company. Follow above directions to treatment system. (Map A)

{Over for maps}

MAP A: Brandonville Fire Company; 10 Main Blvd., Ringtown, PA 17967-9687

Your Invited: Audenreid Dedication (June 17th, 2006)

2006-05-25T08:57:00.000-04:00

On behalf of the Columbia and Schuylkill County Conservation Districts and the Catawissa Creek Restoration Association, it is my pleasure and honor to invite you to the Audenreid Tunnel Acid Mine Drainage [AMD] Treatment System dedication ceremony. This ceremony will be held on Saturday, June 17, 2006 at 1:30 p. m. The event will include an open house and tours beginning at 12:30 p. m. The press will be invited.

The Audenreid Tunnel Treatment System is the largest passive AMD treatment system ever built in Pennsylvania and perhaps anywhere, in terms of amount of water treated. This facility is capable of treating over 14,000 gallons per minute of AMD and, since beginning operation on December 15, 2005, has had a significant positive impact on the water quality of the Catawissa Creek. Fish are now being seen in about 25 miles of stream that have been biologically dead for over 75 years! Needless to say, we are very excited and wish to share our enthusiasm with our partners and the public.

The dedication ceremony will take place at the site of the treatment system rain or shine. Please be prepared for potentially wet weather and uneven terrain. There will be a bus that will transport public participants from the Brandonville Fire Co. in Brandonville starting at 12 p. m. (see Directions in next post).

We would appreciate your RSVP to Columbia County (570. 784.1310 ext. 102) or Schuylkill County Conservation District (570. 622. 3742 ext. 5) ASAP to assist in our planning. Please indicate number of people attending in your party.

This project is the culmination of efforts and support from many government agencies, businesses, and volunteer groups. It is our hope that you will be able to join us in celebrating the rebirth of the Catawissa Creek!

Aerial view of treatment system

2006-05-02T13:15:00.000-04:00

Flushing Aluminum out of the cells

2006-05-02T13:12:00.000-04:00

Water level drops, but still very high. (1 week after blowout)

2006-02-01T08:51:00.000-05:00

Blowout location behind the intake system

2006-02-01T08:49:00.000-05:00

High flows caused blowout at intake

2006-02-01T08:45:00.000-05:00

Extremely high flows, resulting from large amounts of raina nd snow melt, casued a blowout behind the intake system. The intake system was not damaged, but the blowout will need to be repaired and remidied with a water pressure release component.

We are working on getting the siphons to turn off at the same time

2006-02-01T08:43:00.000-05:00

This siphon chambers being filled

2006-02-01T08:42:00.000-05:00

Work started on the siphons in early January

2006-02-01T08:40:00.000-05:00

Settling pond

2005-12-15T14:51:00.000-05:00

water leaving tank via overflow weir

2005-12-15T14:47:00.000-05:00

Settling pond outflow

2005-12-15T14:15:00.000-05:00

The fence is being installed today. The posts for tank 1 and 2 are installed.

2005-12-12T12:38:00.000-05:00

The pH coming out of the overflow tested near 7.0 (up from 4.0).

2005-12-09T11:44:00.000-05:00

The System was shut down to upgrade the overflow channels and to repair some minor leaks in the clean out pipes. The third tank will be tested early next week.

The tank overflows were being tested. The siphons will not be tested until later next week.

2005-12-09T11:28:00.000-05:00

Tank 1 filled as planned (fill time per tank meets the expected 2 hour prediction)

2005-12-09T11:26:00.000-05:00

The Agridrains functioned as expected and successfully controlled the water level of the tanks.

2005-12-09T11:25:00.000-05:00

Another view of the distribution box handling the increased flow.

2005-12-09T11:24:00.000-05:00

We started to test the lines of the system. The valve for the distribution box was closed and both tank 1 and 2 lines were opened.

2005-12-09T11:22:00.000-05:00

The water level was up following the late November rain. The intake was functioning as designed.

2005-12-09T11:20:00.000-05:00

the intake system has been finalized.

2005-12-01T13:24:00.000-05:00

The settling basins are constucted.

2005-12-01T13:23:00.000-05:00

All three siphon chambers are in place.

2005-12-01T13:21:00.000-05:00

The limestone is delivered and placed in tanks. Outlet pipes are being installed now.

2005-10-28T14:05:00.000-04:00

After the recent rain, the elevated water levels are visible at the discharge.

2005-10-28T13:59:00.000-04:00

The siphons are being installed.

2005-10-28T13:58:00.000-04:00

The pipes were run under the gas line (with supervision from Sun Pipeline)

2005-10-21T12:15:00.000-04:00

The siphons are being installed.

2005-10-21T12:08:00.000-04:00

The gate valves for the tank inlet pipes have been installed.

2005-10-21T12:06:00.000-04:00

The Three tanks are nearly filled.

2005-10-21T12:05:00.000-04:00

2005-10-10T16:32:00.000-04:00

The site has weathered the storm

Posted by Picasa

2005-10-10T16:31:00.000-04:00

Valves at distribution tank

Posted by Picasa

2005-10-10T16:30:00.000-04:00

Additional picture of valves

Posted by Picasa

2005-10-10T16:29:00.001-04:00

Valve

Posted by Picasa

2005-10-10T16:29:00.000-04:00

Valves have been installed

Posted by Picasa

2005-10-10T16:28:00.000-04:00

Tanks are 75% full

Posted by Picasa

2005-09-29T17:52:00.000-04:00

Outlet pipes installed

Posted by Picasa

2005-09-29T17:51:00.000-04:00

La Salle University comes to Audenreid for a tour of the project.

Posted by Picasa

2005-09-29T17:50:00.001-04:00

Tank 3 being filled.

Posted by Picasa

2005-09-29T17:50:00.000-04:00

Another view of tank 2.

Posted by Picasa

2005-09-29T17:49:00.001-04:00

Tank 2 almost filled.

Posted by Picasa

2005-09-29T17:49:00.000-04:00

A view of tank 3 as pipes are installed.

Posted by Picasa

2005-09-29T17:48:00.001-04:00

pipes being aligned in tank

Posted by Picasa

2005-09-29T17:48:00.000-04:00

Pipes are being covered with limestone.

Posted by Picasa

2005-09-22T15:33:00.000-04:00

Limestone delivery has started.

Posted by Picasa

2005-09-19T12:49:00.001-04:00

Pipes are being installed in Tank 2.

Posted by Picasa

2005-09-19T12:49:00.000-04:00

Base stone has been installed in all three tanks. Also, all three tanks have been backfilled.

Posted by Picasa

2005-09-15T16:36:00.000-04:00

Overview of Audenreid Treatment System

Posted by Picasa

2005-09-15T16:26:00.001-04:00

Base stone is being spread in tank 1

Posted by Picasa

2005-09-15T16:26:00.000-04:00

Tank 3 is now backfilled

Posted by Picasa

2005-09-15T16:25:00.001-04:00

base stone is delivered to tank 2

Posted by Picasa

2005-09-15T16:25:00.000-04:00

A look inside the distribution tank (outflow pipe)

Posted by Picasa

2005-09-15T16:24:00.000-04:00

A look inside the distribution tank (inflow pipe)

Posted by Picasa

2005-09-12T13:20:00.000-04:00

Panorama shot of the tanks (courtesy of Jim Gotta)

Posted by Picasa

2005-09-08T18:57:00.001-04:00

Tour participants look on as the intake system is explained.

Posted by Picasa

2005-09-08T18:57:00.000-04:00

Jim Gotta explains the system using a model that he has created.

Posted by Picasa

Pottsville Republican Newspaper Article

2005-09-08T18:09:00.000-04:00

SHEPPTON — A $2 million mine drainage treatment system in development could someday turn the Catawissa Creek into a world-class trout stream. "And we're hoping to have the project completed by November," said Thomas J. Davidock, a natural resources specialist with the Schuylkill Conservation District, Pottsville.

The system is being constructed to treat water flowing from the Audenreid Mine Tunnel, about two miles east of Sheppton. Earthmovers and contractors, including James T. O'Hara Inc., Moscow, Pa., have been hard at work at the site since March. "We have about 13,500 tons of limestone coming to the site," said Clayton E. Bubeck, project manager with RETTEW Associates Inc., Pottsville. "We're about two-thirds of the way through the project. Hopefully, before winter we'll see how this system works, be able to tweak it and get it ready to operate." "And by the spring trout season," Bubeck added, "we should see a definite improvement in the Catawissa Creek." The project was initiated in 2001 by the conservation district and the Catawissa Creek Restoration Association. But today, a dozen or more project partners are involved. Representatives from some of these groups met at the construction site Wednesday for a progress report and tour. The Audenreid discharge is the largest discharge in the Catawissa Creek Watershed, with an average flow of 8,478 gallons per minute. And because of it, the Catawissa Creek is on the state Department of Environmental Protection (DEP) list of impaired waterways. According to the plans, water from the tunnel will flow into a treatment system intake structure instead of directly into Catawissa Creek. From there it will be piped to three concrete, circular treatment cells. Each are 120 feet in diameter and 12 feet deep and will be filled with 4,600 tons of limestone. These cells were constructed and installed by Halteman Construction, Lebanon. The acidic water will go in with a pH level of about 4.03. Once treated, the pH will be at 7, or neutral. Called "an innovative passive treatment system," it will utilize new technology to treat the high rate of discharge, and it won't require much in the way of manpower. "The system must be flushed extensively and frequently in order to manage the accumulation of aluminum hydroxide solids and keep them out of the stream," Davidock said. "About every hour and a half, the treatment tanks will be automatically flushed by a series of automatic siphons into a large settling pond to receive the aluminum precipitate. The water will then flow into a second settling pond to provide final polishing before it is returned to the creek." Siphons that can be triggered automatically will keep the treatment cells from overflowing, said James M. Gotta, a member of the Catawissa Creek Restoration Association board of directors. "It does make it so that we don't have to have a manual operation," Gotta said. One obstacle the contractors faced was an underground gas pipe. "Right where we're standing, there's a high-pressure gas line under our feet," Bubeck said from a vantage point a stone's throw east of the treatment cells. "So far, Sunoco Pipeline Co. has been excellent to work with." The land the mine tunnel and treatment system is on is owned by Butler Enterprises, Hazleton. It's currently leased to Paragon Adventure Park and is used by all-terrain vehicles (ATVs) and off-road motorcycles. But Butler Enterprises has given this project the right-of-way on eight acres. In September 2004, the project received a $1.4 million grant from DEP through the Environmental Protection Agency (EPA) Federal Clean Water Act Section 319 Non-Point-Source Pollution Program. Other funding sources included a $150,000 grant from the federal Office of Surface Mining and a $100,000 grant from the state Bureau for Abandoned Mine Reclamation. "Coming up with funding for this project was a challenging feat, because it is the most expensive treatment system that was put on the ground in Pennsylvania for passive treatment," Davidock said. There are a large list of project partners, which include Eastern PA Coalition for Abandoned Mine Reclamation, Luzerne Conservation District, the Schuylkill County commissioners, East Union Township and Blue Knob Rod & Gun Club. "Project partners have really pulled everything together to get this thing off the ground," Davidock said. "I'm just in awe of all the work that's being done here," said Frederick L. Suffian, an EPA program manager based in Philadelphia. "We provide funding. We hope we get it to the right people and the right place. And this is an excellent example of doing just that."

©The REPUBLICAN & Herald 2005

Hazleton Standard Speaker Article

2005-09-08T18:07:00.000-04:00

09/08/05

By KENT JACKSON kent.jackson@standardspeaker.com
Three concrete pools stand empty in a clearing outside Sheppton, but before the year ends, they will be filled with limestone that will restore life to the tainted waters of the Catawissa Creek, Jim Gotta said.
The treatment system that Gotta volunteered to help es-tablish near the outfall of the Audenreid Tunnel is a larger version of a system that al-ready cleanses water at the Oneida No. 1 Tunnel in the Eagle Rock development.
"That’s why we’re confident this will work,’’ Gotta said.
He and other volunteers with the Catawissa Creek Restoration Association began seeking money to treat mine water exiting the Audenreid Tunnel four years ago.
Their efforts helped pull in nearly $2 million and draw to-gether engineers, scientists, government workers and landowners.
People interested in the Catawissa Creek on Wednes-day afternoon checked prog-ress of the project that Gotta said will start treating water by November.
He described the project and pointed out features on a model that he built before walking the site with his lis-teners. They included repre-sentatives from the state De-partment of Environmental Resources, the Schuylkill County Conservation District, the U.S. Environmental Pro-tection Agency, Trout Unlim-ited and the Eastern Pennsyl-vania Coalition for Abandoned Mine Reclamation.
Water from the mouth of the tunnel will flow through three pipes beneath a road to the concrete pools.
Limestone in the tanks will neutralize the acidic water, causing the aluminum ions to form aluminum hydroxide. Aluminum will stick to the limestone, rendering it inert, so engineer Kim Weaver said she designed a way to flush enough water out of the pools to fill two tanker trucks per minute.
"It’s going to come whooshing out and hopefully take the aluminum with it,’’
said Weaver, of Hedin Envi-ronmental in Pittsburgh. "Aluminum is the killer.
It’s very toxic to fish.’’
Removing aluminum should allow trout and the in-sects they feed upon to live in the Catawissa again.
"Schuylkill County is going to have some of the best places to fish in the state,’’ Craig Morgan of the Schuylkill County Conservation District said of the Catawissa, which he called one of the state’s most beautiful streams.
The system will treat up to 8,500 gallons per minute, the average flow from the tunnel and the amount that can pass through holes in a partition at the intake.
If the volume exceeds that rate, excess water will flow to a diversion chamber and re-enter the creek downstream where the treated water will help neutralize it.
The squared timbers that once outlined the opening of the tunnel have collapsed, leaving a few wooden pylons at the base of a steep, eroded hillside.
James T. O’Hara, the gen-eral contractor, burrowed into the hillside with pipes to en-sure future subsidence won’t stop the flow. He heaped clamshell-size stone atop the intake to stop leaves from clogging it.
While excavating the pipe-line trenches, he separated rock that he used to control erosion.
The pipeline passes where a tributary merges with the Catawissa.
Trout fingerlings live in the tributary. They won’t swim into the main stream, but they will after treatment begins.
"As the aluminum gets out, they will come back right away. You don’t have to stock it,’’ Craig Morgan of the Con-servation District said.
Researchers from Blooms-burg University and a biologist from the Susquehanna River Basin Commission are taking an inventory of the insects in the creek and tributaries near the treatment system. Their findings will provide a basis to compare life in the stream af-ter the system starts operating.
The system is the most ex-pensive passive treatment plant in the state, Tom Davi-dock of the Conservation Dis-trict said. It won federal funds because of the persistence of groups like the Catawissa Creek Restoration Association and the project’s potential to bring life to 36 miles of the creek.
Outfall from the tunnel is such a large source of alumi-num that treating it should also help neutralize other sources of pollution, such as the Green Mountain Tunnel.
The Green Mountain Tun-nel discharges perhaps a half-mile downstream from the concrete pools.
While the water quality is poor, its flow isn’t as rapid as the discharge from the Auden-reid Tunnel, Robert Hughes of the Eastern Pennsylvania Coalition said.
The Green Mountain tunnel water meanders into the Catawissa Creek after flowing through a wetlands that Hughes studied.
He said the four-acre wet-land offers a home to blue-winged teals, red-winged black birds, bayberries, blue-berries, and hemlock, pine, and tupelo trees.

2005-09-07T16:41:00.000-04:00

Tour guests look at the project's intake system.

Posted by Picasa

2005-09-07T16:40:00.000-04:00

Jim Gotta explains the treatment system during the project tour.

Posted by Picasa

2005-09-06T15:08:00.000-04:00

Intake system bypass until construction is complete.

Posted by Picasa

2005-09-06T15:07:00.000-04:00

Base stone started to be spread on floor of tank #1.

Posted by Picasa

2005-09-02T08:14:00.000-04:00

AUDENREID CONTACT INFORMATION

For questions or comments regarding the Audenreid project, please contact:

Tom Davidock
Schuylkill Conservation District
1206 Ag Center Drive
Pottsville, PA 17901

(570) 622-3742 ext. 120
fax (570) 622-4009

tdavidock@co.schuylkill.pa.us

2005-09-01T16:59:00.000-04:00

A temporary ramp has been placed on tank 1 to deposit the 2B base stone.

Posted by Picasa

2005-09-01T16:57:00.000-04:00

The forms have been taken off of Tank 3. It will be ready to be backfilled in a week.

Posted by Picasa

2005-09-01T16:55:00.000-04:00

2B stone was delivered for tank number 1.

Posted by Picasa

2005-08-30T19:16:00.000-04:00

On September 7th, the SCD will be hosting a tour of the AUdenreid site. Come see the progress that has been made to date. The tour will be at 1:00pm. If you would like to go or need directions, please contact the Schuylkill Conservation District at (570) 622 3742 ext 120.

2005-08-30T14:13:00.000-04:00

Backfilling the lines

Posted by Picasa

2005-08-30T14:02:00.000-04:00

The pipes start to get connected to the tanks.

Posted by Picasa

2005-08-30T13:26:00.000-04:00

A Picture of the three 18" lines coming from the discharge.

Posted by Picasa

2005-08-30T13:12:00.000-04:00

Tanks 1 and 2 are being backfilled.

Posted by Picasa

2005-08-30T10:44:00.000-04:00

A view of the intake system frombehind the tunnel.

Posted by Picasa

2005-08-30T10:43:00.000-04:00

After the intake system has been installed.

Posted by Picasa

2005-08-30T10:42:00.001-04:00

Another view of the tunnel before the intake system was installed.

Posted by Picasa

2005-08-30T10:42:00.000-04:00

The distribution box has been installed.

Posted by Picasa

2005-08-30T10:40:00.000-04:00

The siphons have arrived (Impressive)!

Posted by Picasa

2005-08-30T10:39:00.001-04:00

As of now, all three tanks have been poured.

Posted by Picasa

2005-08-30T10:39:00.000-04:00

The discharge was buried to prevent soil and other materials from getting into the treatment system.

Posted by Picasa

2005-08-30T10:38:00.000-04:00

The concrete tanks are 120 ft. in diameter and 12 ft. deep.

Posted by Picasa

2005-08-30T10:37:00.000-04:00

The tunnel, once daylighted, was an impressive site to see...It can only be seen in pictures now.

Posted by Picasa

2005-08-30T10:35:00.000-04:00

All three tank floors were poured consecutively..The tank walls were constructed and poured one at a time.

Posted by Picasa

2005-08-30T10:33:00.000-04:00

The discharge was daylighted for the 1st time in more than a decade.

Posted by Picasa

2005-08-30T10:31:00.000-04:00

The pads for the tanks were quickly prepared as soon as excavation was completed. The site had a lot of water so the contractor had to do a lot of extra work to install adequate drainage.

Posted by Picasa

2005-08-30T10:28:00.000-04:00

One large hold was excavated for the three tanks. This took several weeks to complete.

Posted by Picasa

2005-08-30T10:26:00.000-04:00

Road was moved to make room for the concrete tanks. Additional stormwater management facilities had to be installed to handle upslope runoff.

Posted by Picasa

2005-08-30T10:23:00.000-04:00

Construction just starting-Site has been cleared

Posted by Picasa

2005-08-30T10:22:00.000-04:00

Pouring Concrete

Posted by Picasa

Welcome to the Audenreid Blog

2005-08-30T09:09:00.000-04:00

I wanted to find a way to keep everyone updated on the Audenreid project and share pictures on the construction progress. I hope that this blog will serve that purpose. Come back often and check for updates on the system's progress. I will be posting photos regularly.

Thanks
Tom